GM issues 6 more safety recalls

86600 full
86600 full

General Motors issued six more recalls on Wednesday, bringing its annual total to 60 recalls covering almost 30 million vehicles.

The latest recalls cover almost 718,000 cars and trucks. The largest is for faulty seats in just over 414,000 cars and small SUVs. Other problems include incomplete welds on seat brackets, turn signal failures, power steering failures, loose suspension bolts and faulty roof rack bolts.

GM is conducting a companywide safety review as it tries to correct a dysfunctional corporate culture in which safety was a low priority.

GM's spate of recalls comes after trial lawyers discovered that the company knew about a deadly small-car ignition switch problem for more than a decade, yet failed to recall the cars until this year. The company says 13 people have died in crashes linked to the switches in 2.6 million older small cars, but lawmakers and lawyers say the death toll is closer to 100.

The company has set up a fund to compensate victims. The bungled recall has brought investigations from the Justice Department and Congress, as well as a maximum $35 million fine from the National Highway Traffic Safety Administration for delays in reporting problems to the agency.

Even before Wednesday, GM had passed its old full-year record of 11.8 million vehicles recalled in 2004. The company also pushed the total number of vehicles recalled in the U.S. by all automakers well over the old record of 30.8 million vehicles, also set in 2004. Automakers have recalled more than 33 million vehicles so far this year.

Recall list

Here are the models GM announced Wednesday in a news release, listed according to the problem that led to their recall:

Adjustable height seats

414,333 2011-2012 model year Chevrolet Camaro; 2010-2012 model year Chevrolet Equinox and GMC Terrain; 2011-2012 Buick Regal and LaCrosse; and 2010-2012 Cadillac SRX models in the U.S. equipped with power height adjustable driver or front passenger seat structures. In these vehicles, the bolt that secures the height adjuster actuator may become loose or fall out. If the bolt falls out, the seat will move up and down freely because it is no longer attached at the height adjuster. The vehicles are safe to drive, but customers should not use the power height adjustable feature until dealers can replace the height adjuster bolt. GM is aware of one crash and three injuries but no fatalities related to this condition.

Incomplete weld on the seat hook bracket

124,007 model year 2014 Chevrolet Caprice, 2014 Chevrolet SS, 2014-2015 Chevrolet Silverado LD and HD, 2013-2014 Cadillac ATS, 2014 Cadillac CTS, 2014 Cadillac ELR; 2013-2014 Buick Encore; and 2014-2015 GMC Sierra LD and HD vehicles because certain vehicles may have an incomplete weld on the seat hook bracket assembly. A loss of power to a laser welding machine may have resulted in an incomplete weld, according to data collected from the machine between July 2013 and January 2014. Dealers will inspect the weld. If it is sufficient, no further action is necessary. If it is insufficient, dealers will replace the lower seat track at no charge. Less than 1 percent of welds are expected to require seat track replacement. GM is unaware of any crashes or injuries as a result of this issue.

Front turn signals

120,426 2011-2013 model year Buick Regal and 2013 model year Chevrolet Malibus equipped with front turn signals that use two bulbs in each front turn signal. While the driver would get a rapidly flashing turn signal arrow in the instrument cluster if both bulbs in one turn signal were burned out; if only one bulb on either side burns out, there would be no signal to the driver. Dealers will reprogram the body control module to fix the condition. GM knows of no crashes, injuries or complaints related to this issue.

Reduced or no power steering assist

57,242 2014 Chevrolet Impalas equipped with belt-drive electric power steering. On certain vehicles, customers may experience reduced or no power steering assist at start-up or while driving due to a poor electrical ground connection to the Power Steering Control Module. If power steering is lost, a warning message is displayed on the Driver Information Center and a chime sounds. Steering control can be maintained because the vehicle will revert to manual steering mode, but would require greater driver effort particularly at low vehicle speeds. Paint may have seeped behind the nut on the power steering control module ground stud. Dealers will inspect and clean paint from behind the ground nut, re-torque the nut and update the power steering control module software at no charge. GM is aware of one crash but no injuries or fatalities related to this condition.

 Lower control arm bolt not fastened

1,919 2014-2015 Chevrolet Sparks imported from Korea that were assembled with a lower control arm bolt not fastened to specification. The condition could result in noise from the front suspension and separation of the lower control arm from the steering knuckle while driving resulting in loss of steering control. Dealers will inspect the left and right hand lower control arm attaching bolts to assure they are tightened to specification. GM knows of no crashes, injuries or fatalities related to this condition.

Wrong retaining nuts in roof carriers

22 2015 model year Chevrolet Tahoe/Suburban and GMC Yukon/Yukon Denali vehicles in the U.S. In these vehicles, the roof carriers may have been attached with the wrong retaining nuts, resulting in holes or tears in the roof rail air bags if they deploy. Eight of these vehicles are in dealer stock and will be repaired before being sold.

blog comments powered by Disqus